G55+MDHA32DSF现货 in stock! 欢迎来电咨询~！！

G55+MDHA32DSF,

G55+MDHA32DSF

有福之州-福州聚福兴供应进口工业控制系统成套备件：DCS PLC模块卡件，底板机架机槽，CPU模块，输入输出模块，模拟量模块，电源模块，通讯模块，工业交换机，触摸屏人机界面显示器，插头连接器，连接电缆接插电缆，伺服控制器，电机马达，伺服驱动器，驱动板电源板电路板，采集卡，影像卡，工控机，示教器，工业机器人配件..........
有福之州-福州聚福兴供应自动化供应进口品牌：罗克韦尔AB， Prosoft，西门子SIEMENS，施耐德SCHNEIDER，通用电气GE FANUC， 发那科FANUC，安川Yaskawa，欧姆龙Omron，三菱Mitsubishi，基恩士Keyence，东方步进Vexta，迈创Matrox，美家仪器NI，研华Advantech，莫迪康Modicon，思科Cisco，大隈Okuma，瑞士ABB，力士乐 Bosch Rexroth，台达Delta，福克斯波罗Foxboro，富士Fuji，霍尼韦尔Honeywell，惠普Hp，瑞恩 Reliance...........

欢迎咨询~~~~~

　　1 引言

　　纺丝机纺出的涤纶原丝需经过牵伸定型后,才具有一定的纤度、强度、伸度和其它的物理性能。VC443A牵伸加捻机用于涤纶复丝生产过程中牵伸加捻工序。牵伸丝为低捻复丝，可直接或经加弹工序后供绸厂使用。它的电气部分由电源控制系统、程序控制系统、锭子交流变频调速系统、热盘控制系统、热板控制系统组成。随着机电一体化技术的发展，对系统的可靠性要求愈来愈高，因PLC具有控制可靠、体积小、功能强、速度快,组态灵活和可扩展性的特点而得到了广泛的应用，成为自动化系统中的基本电控装置，故VC443A牵伸加捻机选用PLC可编程控制器，实现了生产的自动控制。

　　2 PLC选型设计

　　系统选用了日立公司的产品:E-64HR可编程控制器,作为主控单元，它有64个输入/输出点,其中40个开关量输入点，24个输出点，内置式电擦除EEPROM可以保护用户方便的完成程序和参数的修改和存储, PLC根据各输入点所接按钮，接近开关，接触器等电器信号的状态以及编制的软件程序自动控制各电机，电磁阀，指示灯等，完成整个生产的工艺动作程序，钢领板换向及成型自动控制。E-64HR具有多种编程工具:通用编程器PGMJ-R和标准编程器PGNJ等，体积小携带方便，可在现场实地进行程序调整和传送。全部控制程序约276条，可见该系统软硬件资源得到了相当充分的利用。

　　3 VC443A牵伸加捻机工艺

　　3.1 输入信号

　　VC443A牵伸加捻机控制系统的输入信号:主令按钮、限位开关、接近开关、钮子开关、拨盘开关的投入信号，全部为直流输入，共有40点。

　　3.2 输出信号

　　控制的负载主要分成三类:一是7台交流电机:牵伸双速电机M1、油泵电机M2、靠模升电机M3、靠模降电机M4、移丝电机M5、锭子电机M6、风机M7;二是用于控制钢领板升降及侧压辊压差的电磁阀;三是信号灯;四是计数器，共有24点，全部为继电器接点输出信号。

　　3.3 开车主要控制过程

　　(1) 按“油泵开”按钮SB7，使接触器KM5吸合， 油泵开指示灯亮, 油泵电机M2运转。(程序器的输出50对应的LED发光)。

　　(2) 按“低速开”按钮SB9。

　　●辅助接触器KA1吸合，锭子低速运转。(程序器的输出51对应的LED发光)

　　●程序器控制下，使计数器复零，进入准备工作状态，内部定时器T01 T02接通，使钢领板强迫进入废丝盘位置，待TO0延时到断开快速阀YV3，钢领板在程序器控制下微动。(程序器的输出76、65对应的LED发光，延时到熄灭，66、67对应LED交替发光)

　　●定时器TO1延时到，使接触器KM3吸合，牵伸双速电机M1带动牵伸罗拉和上下牵丝盘低速运转，低速指示灯亮，进入挂丝阶段。(程序器的输出52对应的LED发光)

　　(3) 按“高速开”按钮SB11。

　　●辅助接触器KA2吸合，使锭子高速运转。(程序器的输出53对应的LED发光)

　　●程序器控制使电磁阀YV4断电，侧压辊加压。(程序器输出64对应LED发光)

　　●定时器T02接通，延时到后接触器KM4得电，牵伸双速电机M1切换为高速运转，高速指示灯亮，继电器KA3吸合，移丝电机M5运转。(程序器输出54对应的LED发光。55对应的LED发光)

　　●定时器T03延时到后，钢领板强迫上升，靠模上撞块使底部打结开关SA2接通，定时器T04得电，使上升阀失电，实现底部打结，T04延时到上升阀YV1/1再次得电，强迫钢领板快速上升，进入正常牵捻区，待T05延时到后切断快速阀YV3，钢领板在程序器控制下，以正常速度运动，同时接通继电器KA4，靠模升电机M3运转，带动靠模缓慢上升，计数器开计长(程序器56对应的LED发光。65对应的LED在接通快速阀时发光，74对应的LED发光，有计长信号时发光指示)。

　　至此开车过程结束，机器进入正常纺丝。
 

ADAM-3013

Dialogic D/300JCT-E1-75 D300JCT

IMBA-8650GR-R22-SZ

P945G(C) 1.0 (S1.3)

PCIE-8361

NANO-LUKE-1G-R10

1492-NM40BL TERM BLCK End Barrier

通用型变频器 6SE6 420-2UD25-5CA1 "5.5 KW，185 x 245 x 195"

软启动器 3RW44456BC45

ET 200SP 7MH4138-6AA00-0BA0 称重模块 SIWAREX WP321

1585D-M4TBDM-50 Micro D-Code, QD Style Ethernet Media

1756-EN2TRXT ControlLogix XT Dual Port EtherNet/IP Mo

1794-OE4 Flex 4 Point Analog Output Module

194E-CA63E-P11 194E Load switch

2085-OW16 Micro800 16 Point Relay Output Module

2090-DANFCT-S09 TL-Series 9m Feedback Cable

ABICTAE0000/SER 10.5 Inch Color TFT, TCP Label, 110VAC, with AB Serial Cable

GC646PCMKIT GlobalCare Complete for Proficy Change Management Starter Kit (1 user, Scheduler)

HE697BEM600 Discontinued Part. Check with GE IP on migration path.

IC630MDL366RR Analog Output Module, 4-20mA (2 channels)

IC647HSTSS5KM Historian Standard Server 5000 Points (M4 Key)

IC660BLC001 Cable w/Connectors Alpha 9823 15 In (Qty 3)

IC695ALG728 Analog Output HART Module, 8 channels,that is configurable for voltage, current, current/HART configured for Current: 0 to 20mA, 4 to 20mA; Voltage: +/- 10VDC, 0 to 10VDC per channel non isolated. Up to 16 bit resolution. Requires high capacity ter

IC756WDV009K-23 DV Development Sys Visual Basic, Korean, Version 2.3

CompactLogix System 1769-CLL1 1 FT (305 MM) LEFT-TO-LEFT BUS EXPANSION CABLE

PLC-5/1771 System 9399-RL53GRDE RSLOGIX 5 GETTING RESULTS GUIDE(GERMAN)

Distributed I/O D1794-6.5.3 FLEX I/O REMOTE I/O ADAPTER MOD. USER MANUAL

Operator Interface 2711P-T6M5A PV PLUS 600 GRAYSCALE, TOUCH, RS232, AC PS

Support 6404-DDMCS SUPT RENEWAL CONTRACT FOR 6404DDMC

Support 9358-PLTM2100R SUPT REINSTATEMENT CONTRACT FOR 9358PLTM2100ENE

Support F1784-CPCIDS FIRMWARE UPGRADE FOR 1784-CPCIDS COMMUNICATION MOD

RSI Software Products 9301-2SE2200DEU1 RSVIEW32 WORKS 150-300 UPGRADE IN-SUPT (DE)

RSI Software Products 9701-VWSB000AJPE RSVIEW SE STATION UNLIMITED DISPLAY (JAPANESE)

RSI Software Products 9399-APSIE SLC 500 APS IMPORT/EXPORT UTILITY USER MANUAL

Motion Control 2098-DSD-HV220 HIGH VOLTAGE DRIVE, 47A/94A, ULTRA3000

ABK3D200C2P/DVN QUICKPANEL 6" TFT W/DVN

IC220TBK123 I/O TERMINAL STRIP, 12 POSITION SPRING STYLE W/COLOR, OUTPUT, QTY 10

IC752DPH000RR Datapanel H, 640x200 LCD with CCFT backlight. Text, bitmaps, bar graphs, real time clock. Includes integrated keypad. No touch capability.

MTR-3S33-G-R-B-E-S MTR series servo motor with resolver and brake and shaft seal

NI 9852

SBC8173

ADAM-4080

NIDEC-READ MC-030F36

FSC-1814 PCA-6010VG

EP-7KXA

1492-J6FB124 Fuse Terminal Block with LED

1492-TP28 IEC Term Blck Test Plug

软启动器 3RW40742BB34

CPU 模块 6ES7 677-2AA40-0AA0 CPU 1515SP PC，4GB 备件 *

153H-C317XBD-56 SMC-3 ENCLOSED COMBINATION 317A

1746-A10 SLC 10 Slots Chassis

1786-BNCJ CNet Media Jack-to-Jack TNC Connector

193-T1AA40 0.25-0.4 A IEC Bimetallic Overload Relay

20-COMM-Q PowerFlex ControlNet Fiber Media Adapter

2090-CSBM1DF-10AF09 Kinetix Cable Single DSL 2090-Series

20AC011A3AYNANC0 PowerFlex 70 AC Drive 20A

GA647IFSTRNUNLMT GCA iFIX Std HMI Unlmt Run

GP647IFPLSR00150 GCP iFIX Plus SCADA 150 I/O Srv

IC600BF942RR -10Vdc to +10Vdc Analog Output Module (4 channels)

IC647HSTCR50KM Collector Redundancy Option for Historian - Standard Server 50000 Points (M4 Key)

IC647TPR935 CIMPLICITY HMI ProServer 35,000 I/O Runtime System

IC693PTM100CA Conformal Coated Power Transducer Module

IC756MDV001J-97 DV Development - Alpha OpenVMS Addt'l User, Japanese, Version 9.7

MicroLogix 1000/1761 System 1761-NET-DNI DEVICENET INTERFACE (DNI)

PLC-5/1771 System 1771-NBV1 HIGH RESOLUTION ISOLATED ANALOG MODULE

Distributed I/O 1792D-CB18JP MAXUM ROUND MEDIA 18MM BASE, PASSTHRU FOR DNET

Communications 9351-HPUSRT INTERCHANGE FOR HP-UX RUNTIME

Operator Interface D6190-6.5.25 CONTROLVIEW AND CONTROLVIEW 300 INSTALLATION MNL

Support 9358-B03R SUPT REINSTATEMENT CONTRACT FOR 9358B03ENE

Support 9392-CDRSFRU UPGRADE TO ENGLISH/FRENCH BUNDLE

RSI Software Products 9323-L2300DUR UPGRADE: OUT-SUPT: 6200-2 BOTH TO AI-2 BOTH

RSI Software Products 9301-2SE3500PTE RSVIEW32 RUNTIME 100K (PORTUGUESE)

RSI Software Products 9356-SQLSAPALENE RSSQL FOR SAP SOLUTIONS SERVER PREMIUM

Motion Control TL-A230P-BJ34AA MOTOR, SERVO, 1.3NM, 5000RPM, 17BIT SERIAL FEEDBAC

44A739462 Series 90-30 State Logic CSE311 Upgrade to latest revision

IC200CHS003 I/O CARRIER CONNECTOR STYLE

IC694MDL390 OUTPUT MODULE 120/240 VAC 2AMPS 5 POINT ISOLATED

MSI-UNIV-WEB-25-43 Univ Web(RTIP/Dash/Web/Excel) 25 Pak-43

cFP-PG-522

AMB-2000

DRC 1000 DRC 700-1000

X8DAL-3

PCI-10S PCI-6S PCI-7S PCI-8S

SF7305 SYS71838

lnterface IBX-8501

1492-SPM2C040 MCB Supplementary Protector 4 A

软启动器 3RW30261BB04

电机启动器 3VU16402MP00

150-F135NCD SMC Flex Smart Motor Controller

1732D-IB16M12M12 ArmorBlock 16 Point Input Block

1771-OGD 1771 16 Point Digital Output Module

193-ED1DB E1 Plus 3.2-16 A IEC Overload Relay

199-FSA Panel Mount Adapter

2090-CPWM7DF-08AA01 MP-Series 1m Standard Power Cable

2094-SE02F-M00-S0 Kinetix 6200/6500 Control Module

DT1005-1 Industrial Keyboard Mounting Brackets (DT1005&DT1000-12a ONLY)

GFK-1044 Series 90-70 VME DLAN/DLAN+ Interface Module User's Manual

IC210NDD024 24V DC Power Source, (12) 24VDC in/(8) out (Transistor) , (4) analog inputs, not expandable, without LCD/Keypad. The unit has no cover over components.

IC647BR3M BR3:Bristol Babcock

IC647PRTHE005M Proficy Portal Historian Edition Client Pack 5 Users (M4 Key)

IC693CPU360RR CPU 360 Module (240K Bytes configurable user memory, 4K I/O, 8 racks), no built-in Serial Ports

IC756ADV000E-97 DV Development - AIX Op Sys, English, Version 9.7

MSI-EFF-2-43 Efficiency Mang Clients 2 Pack-43

SLC/1746 System 1746-RL61 REPLACEMENT OCTAL LABEL KIT FOR CTLG # 1746-IV32

Distributed I/O 1734-TBQ10 10 MODULE BASES W/ REMOVABLE IEC SCREW TERMINALS

Application-specific products 9307-EMRTENE RSENERGYMETRIX REAL TIME

Operator Interface 2711-NF2C FUNCTION KEY STRIP PV900 COLOR

Support 9302-MODS SUPT RENEWAL CONTRACT FOR 9302MOD

Support 9510-PBEWENS SUPT RENEWAL CONTRACT FOR 9510PBEWEN

DeviceNet Products 1787-MCABL MINI-CONNECTOR CABLE FOR 1770-KFD

RSI Software Products 9301-2SE3350U3R UPGRADE: OUT-SUPT: RSVIEW32 RUNTIME 1500 TO 5000

RSI Software Products 9310-TSTNDENE RSTESTSTAND

Motion Control MPG-A004-031M24 MOTOR,SERVO,GEAR RATIO 31,14NM,194RPM,MULTI,BRK

Silver Series 1756-L1M1 LOGIX5550 PROCESSOR WITH 512KBYTE EXPANSION MEMORY

HE693GEN251 Genius interface board for new generation AV300/DV300 drives (external mount)

IC648MNT071 Annual Software Maintenance for LM 90-70 Parallel Communications

QPI31200C2P QUICKPANEL COLOR 10.5" TFT

ST-4424 STXi analog output module 4 Channels, 0~10Vdc, 12bit

USB-6281

PCL-734

Nematron MB820-R

GIN-6350P R2G-6350P

HP-W460GC33

OC-B2P0-CV000

1492-RXIMTR4024-32R Mech Relay Digital Interface Module

WinCC 上位监控软件 6AV6381-1BS06-0DV0 "WinCC?V6.0 RC?8K （8K 外部变量）"

6ES78221AA030YA7

1497B-A10-M15-0-N Control Power Transformer

1606-XLS180B AC or DC Input 12 to 15VDC Out 180W PS

1769-ARM CompactLogix Address Reserve Module

188-K4D040 Miniature Circuit Breaker 4 A

194R-C30-1753-PYN1 194R Disconnect Switch

2090-CPBM7DF-10AF30 MP-Series 30m Continuous-Flex Cable

2090-XXNPMP-14S20 MP-Series 20 m Length Power Cable

CBL-14-ED-30 Encoder cable for MTR-1235 or MTR-1300 or MTR-1400 or MTR-1N series splashproof stepping motors connected to IMC or S2K. 30 feet

GEK-90486-1 Genius I/O System and Communications User's Manual - Volume 1

IC200TBM005 I/O auxiliary spring clamp style

IC646TBLSS5K Proficy Troubleshooter for Intelligent Historian for Hist 5000 Points

IC647NMF000 Mitsubishi Melsec OPC Server

IC693ACC309 Rack Adaptor Bracket, Series One 5 and 10 Slot Racks

IC750CTR200RR PANELWARE Basic Panel Controller

IC800VMCB3050 Motor power and brake power cable for 3 kW VersaMotion servo motor- 5 meter

SLC/1746 System 1746-OB16 DC OUTPUT MODULE FOR PROGRAMMABLE CONTROLLER

Industrial Computers 6155R-7S2KH VERSAVIEW NON-DISPLAY COMPUTER

Application-specific products 6556-SCBM SLC PROGRAMMABLE PRESS CONTROL KIT

Operator Interface 2711-B6C1 PV600 COLOR KEY&TOUCH, RIO & RS232 PRINT

Support 9301-2SE2300FRS SUPT RENEWAL CONTRACT FOR 93012SE2300F

Support 9307-8MGDBCR SUPT REINSTATEMENT CONTRACT FOR 93078MGDBCENE

DeviceNet Products 1734-ADNX 24V DC DEVICENET ADAPTER WITH SUBNET EXPANSION

RSI Software Products 9301-2SE250JPU2R RSVIEW32 WORKS 1500-100K UPGRADE OUT-SUPT (JP)

RSI Software Products 9358-BNT10U1R UPGRADE: OUT-SUPT: RSBATCH 03 TO 10

Motion Control MPL-B320P-MJ24AA MOTOR,SERVO,2.94 NM,5000RPM,MULTI,460V,BRK,5.1KG

Motion Control 2090-XXNPY-16S20 CABLE,NON-FLEX,MOTOR POWER,Y,16 GAUGE,20M

GFK-0402 Hand-Held Programmer Series 90-30/20/Micro Prog. Control User's Manual

IC641VPP750 VersaPro Professional Edition 50 Pack - Windows Programming Software for Series 90-70, Series 90-30, and VersaMax PLCs

MSC-C-C Obsolete- 4-20 mA in / 4-20 mA out

PSPC-DC25/E-220 Prof Shop Floor SPC DC 25 User eSig 220v

PXI-8432/4

61-600695-000

iBASE IB500

BPS-250MA2

GVPC3

MB896F-R

1492-MW9X24 IEC 9 x 24 mm Cable Marker Card

通讯处理器CP 6ES7 341-1AH01-0AE0 CP341，标准串行通讯模块，RS232C 接口，最高76.8kbit/s,9 针Sub-D 型接口,可加载 ModbusRTU及 DataHighway 驱动

行程开关 3SE53220SJ23

TIA 博途 WinCC 选件 6AV2107-0CP00-0BB0 SIMATIC WinCC Sm@rtServer for SIMATIC Panels

1585J-M8HBJM-0M3 RJ45 Ethernet Media

1756-TBNH ControlLogix 20 Pin Screw Terminal Block

188-K1D500 Miniature Circuit Breaker 50 A

194E-Y40-1756-6N 40 A 194E Load switch

2090-CFBM7E7-CEAF30 30 m Length SpeedTec Extension Cable

2090-UXNPBMP-10S09 MP-Series 9 m Length Power Cable

BC647MBL001 Machine Edition Lite Development Suite with Proficy GlobalCare Complete and USB Hardware key

GC647IFPRDV00075 GCC iFIX Profsnl SCADA 75 I/O Dev

IC200CHS001 I/O carrier barrier style

IC646MPT001 GE Compare Single License

IC647IFSTDV00075M iFIX Standard HMI 75 I/O Development (M4 Part)

IC670ALG310RR Analog Output Voltage, 8 Channel, +/-10V, 0 to 10V

IC697CPU788 GMR Redundancy CPU, 386, 100 Triplex (voted) I/O,

IC800S2K4DSTRKIT S2K series controller starter kit with 4.3 amp Devicenet controller

ControlLogix/1756 System 1756-OV32E 10-30 VDC ELEC FUSED SINKING OUTPUT 32 PT (36 PIN)

Industrial Computers 6182H-10KRH4D VVCE 1000, KEYPAD, STD MEM, ENET, DC

Process Control 1757-FIMEXP100 FOUNDATION FIELDBUS FIM MODULE EXPANSION

Operator Interface 2711P-RDB7C PV PLUS 700, KEY/TOUCH SCREEN DISPLAY MODULE

Support 9355-WABDER SUPT REINSTATEMENT CONTRACT FOR 9355WABDE

Support 9351-WESRTR SUPT REINSTATEMENT CONTRACT FOR 9351WESRT

ControlNet Products 1747-KFC15 SLC CNET SERIAL INTERFACE MODULE

RSI Software Products 9301-2SE2400ITE RSVIEW32 WORKS 32K (ITALIAN)

RSI Software Products 9355-WABOEMEU1R UPGRADE: OUT-SUPT: WINLINX TO RSLINX OEM CD

Motion Control MPL-A320P-HJ22AA MOTOR,SERVO,2.94NM,5000RPM,ENCDR,230V,4.0KG

Motion Control 2090-U3AE-D4409 CABLE,TWO AXISTO LOGIX 1756MOAE2 CARD,9M

CBL-119-1 Cable.SIMATIC T.I. 305 DCU (RS-422)

IC5105KAX0000 Panel C Industrial Computer 15" Unbundled with WIN XP

IC800PCUBC10S050 PowerCube Flying Lead Interface Cable, 1000 Steps/Rev & Power Save Enabled, 5 Meters

OC647IFESGDV00300C iFIX Optn: ESig & ERec 300 I/O Development (M1Component Part)

PCI-MIO-16XE-10

845GV P4I845GVE-L

PCA-6166

contec MB-PCI3/3(PC) PCI-ISA

BPP-P2I6

R1S2-5300V4V

1492-M6X10V101-200 Connection Products

1494HL-EN3H2 General Duty Safety Switch

软启动器 3RW44466BC36

ET 200SP 6ES7193-6BP00-0BD0 基座单元 BU20-P12+A0+0B，类型D0，直插式端子，适用于电能测量模块，20mm宽

1585D-M4TBJM-28 Micro D-Code, QD Style Ethernet Media

1756-HSC ControlLogix High Speed Counter Module

1794-PS13 Flex Power Supply

194E-DA16E-TN-PE 194E Load switch

2090-CDNFDMP-S05 MP-Series 5 m Length Feedback Cable

2090-DAPC-D0909 Ultra 1500 9 m Length PC I/f Cable

AD641ECL321 ECLiPS Programming Software for the Series 90-30 SLP with OnTOP

GC646PME001 GlobalCare Complete for PCM Machine Edition Version 1 User

HE800ACC116 Cage-clamp (screw) style I/O plug, 16-terminal. (Qty 10)

IC640BVB317RR Video Board for FactoryMaster

IC647HSTSSEO1750KM eSignature Option for Historian - Standard Server 1,750,000 Points (M4 Key)

IC660BLM508 Bus Terminator 75 Ohm (Qty 4)

IC695CMX128 Control Memory Xchange Module 128Megbytes of user shared memory.

IC756WET200E-22 Custom Datasource Toolkit, English, Version 2.2

CompactLogix System D1769-UM004AENP COMPACT THERMOCOUPLE MOD.

PLC-5/1771 System D1771-6.5.119 U.MNL.INTRINSICALLY SAFE

Process Control 1757-FIMRTPBASE FIELDBUS INTERFACE RTP BASE

Operator Interface 2711P-B7C6D1 PV PLUS 700, KEY/TOUCH, RIO/DH, DC PS, STD MEM

Support 6500-PS7PTS SUPT RENEWAL CONTRACT FOR 6500PS7PT

Support 9358-PLTMCLTR SUPT REINSTATEMENT CONTRACT FOR 9358PLTMCLTENE

Support F1785-KA3 FIRMWARE UPGRADE FOR 1785-KA3 COMMUNICATION MODULE

RSI Software Products 9301-2SE2200U1R UPGRADE: OUT-SUPT: RSVIEW WORKS 150 TO 300

RSI Software Products 9701-VWSB000JPU2 RSV SE STATION 100 - UNLTD DISP UPGRADE (JAPANESE)

RSI Software Products 9399-EDS2TUT RSWIRE TUTORIAL/BASIC OVERVIEW

Motion Control 2098-DSD-005X-DN DRIVE, 2.5A/7.5A, ULTRA3000 W/DEVICENET/INDEX