260MF-2现货 in stock! 欢迎来电咨询~！！

　　工业循环水轧钢工业中占有非常重要位，其水温高低直接影响到加热炉和轧机等设备安全和使用寿命。为及时准确对循环水进行监控，莱钢轧钢厂中小型车间水处理采用浙大中控SUPCON JX—300X DCS控制系统。DCS控制系统把计算机、仪表和电控技术融合一起，实现了数据自动采集、处理、工艺画面显示、参数超限报警、设备故障报警和报表打印等功能。并此基础上开发了针对循环水温温度闭环控制。
　　2、系统介绍
　　SUPCON JX—300XDCS采用高速工业以太网Scnet作为其过程控制网络，系统由工程师站、操作站、控制站、过程控制单元等组成，配置灵活。水处理系统规模，水处理SUPCON DCS系统设计了1个控制站，1个操作站设置安全级别可兼做工程师站)，构成两级结构。控制站是现场级，直接与现场设备交换数据，完成整个工业过程实时监控功能。操作站(兼工程师站)是监督控制级，即可完成对系统组态、又可实现对现场级检测、控制、保护功能管理。SUPCON JX—300X DCS系统SCKey组态软件是一个全面支持该系统各类控制方案组态软件平台。 SCKey组态软件可完成整个系统控制站组态(系统I/O组态、控制方案组态等)、操作站组态(画面设置、系统流程图组态、系统报表组态等)。系统构成如图1所示。
　　3.1 方案设计
　　从生产热线循环回来工业水流入1#、2#吸水井散热，并吸水井塔顶1#和2#风机进行降温，然后1#、2#吸水井底部共用一个出水管为下一个工序供水，水温要求控制30oC以下。本系统吸水井出水管处安装Cu50热电阻对水温检测，把温度信号T1送入DCS处理器，控制规律运算后给出控制信号，控制变频器来改变电机输入电压频率，来改变电动机转速，带动风机降温，构成一个闭环温度控制系统。变频器选用两台日本SANKEN(300KW)通用型变频器，控制原理如图2所示。
　　循环水吸水井底部热交换特点，对1#、2#吸水井两台风机电机进行主/副控制，主/副电机不同速度曲线驱动风机运转。1#、2#电机可互为主/副电机选择，极大方便了操作工操作。
　　3.2 软件实现
　　为方便操作人员操作，操作站创建循环水温度监控画面，可线显示循环水温度、变频器速度反馈、报警等，进行1#、2#风机电机启停控制和主/副选择控制。并切换安全等级线修改主/副电机控制回路中温度、转速等控制参数。
　　针对循环水温度调节存大滞后性特点，对1#、2#风机电机采用分段控制方法，主/副电机控制曲线如图3所示：当循环水温度低于20oC时，主/副风机电机变频器输出电压频率均为20HZ。当循环水温度变高时，主控制回路中变频器输出电压频率跟随增大，当循环水温度高于24oC时，主电机全工频运转。副电机循环水温度升至23oC时，副控制回路增大副电机输入电压频率，提高风机转速，当循环水温度高于28oC时，副电机全工频运转，与主电机一起为循环水快速降温。

SIEMENS DIGITAL INPUT MODULE 6ES5421-8MA12 SEALED

RELIANCE ELECTRIC 0-57405-C USPP 057405C

SIEMENS SIMATIC 6ES5451-4UA14 SIMATIC S5 OUTPUT MODULE 6ES54514UA14

SIEMENS Simodrive Sinumerik 6SC 6100-0GB11 Power Supply Board

Prosoft MVI94-MCM Modbus Communication Module

Chevy-Pontiac-Saturn OnStar Communication Module ECM

SIEMENS SIMODRIVE 6SN1145-1AA01-0AA2SINUMETIK 840D NCU-BOX 6FC52476FC5356 #BBB

SIEMENS SIMODRIVE 6SN1145-1AA01-0AA1SINUMETIK 840D NCU-BOX 6FC5247-0AA00-0AA2

ADVANTECH PCA-6179 Control Card REV.B1

ALLEN-BRADLEY 2711-T6C2L1X TESTED!! PANELVIEW 600 TOUCH SCREEN

ABB 3HNE 00313-1 ROBOT TEACH PENDANT S4C BACKLIGHT

ACCURAY ABB 67452-003 MCP BOARD 067452-003 67452003 067452003

A20B-8101-0200 and original Fanuc circuit board in good in condition

813S-V0B ALLEN BRADLEY RELAYS REMANUFACTURED

SIEMENS 6ES7-416-2XK02-0AB0 USPP 6ES74162XK020AB0

ASEA BROWN BOVERI 6205BZ10100K USPP 6205BZ10100K

ALPHA GEAR DRIVES SP-180-MF1-10-141-00 USPP SP180MF11014100

METRA INSTRUMENTS 611-0012-000 NSFP 6110012000

HPM 1D703-0031 USPP 1D7030031

ALLEN BRADLEY 1771-PM USPP 1771PM

SIEMENS 6ES5-184-3UA11 USPP 6ES51843UA11

Siemens 6ES5-385-8MB11 USPP 6ES53858MB11

SIEMENS 6ES5 454-4UA12 -FS- 6ES54544UA12

SIEMENS 6ES5 453-8MA11 Digital Output

Siemens PLC 6ES5-421-8MA11/6ES54218MA11

SIEMENS 6ES7 322-1BH81-0AA0 6ES7322-1BH81-0AA0 FreeShip

Siemens PLC 6ES7 331-7KF01-0AB0 6ES7331-7KF01-0AB0

PVDM3-64 CISCO 64 -Channel Voice and Video DSP Module

GSM/GPRS Modem Pool 16 Ports USB interface Wavecom Module AT Commands Q24plus

Unico 100-732.1 Interface Module BOARD 4 available FREE

Siemens 6AV6 640-0AA00-0AX0 6AV66400AA000AX0 TD400C

SIEMENS LASER SCANNER 3SF7834-6PB00 3SF78346PB00

MTT 11-SLOT-RACK

Schneider Modicon DAP 218/AS-BDAP-218 TSX PLC Output module card out dis

Schneider Modicon AS-P371-002 Memory Module

Schneider Modicon AS-E680-914 USPP ASE680914

Schneider Modicon GOULD AS-B550-001

Schneider Modicon AS-B804-016 115 VAC Output Module 16Pt WARRANTY-GUARENTEED

Schneider Modicon Output Module Reed Relay AS-B840-108

Schneider TWIDO TWDLMDA40DUK

Schneider Modicon TSXP575634M in Box

SiemensSimaticS56ES5441-7LA11DigitalOutputModule32x24VDC0.5A

SIEMENS 6AV6-643-0DD01-1AX0 10" MULTIPANEL DISPLAY

SIEMENS NCU-BOX 6FC5247-0AA00-0AA2 SINUMERIK 840D/DE

GE Fanuc PLC Communications Control Module IC693CMM311N

SIEMENS Simodrive Part# 6SN1112-1AC01-0AA1

SIEMENS SINUMERIK 6FC5203-0AF02-0AA1

SIEMENS Moore APACS Resistance Temperature Module RTM 39RTMCAN 16207-61/01

Allen-Bradley Panel View 600 Plus

A-B # 140U-Q6X3-D35 / C-H # HLD3350 3POLE 350AMP

ABB/ Allen Bradley/Stromberg 586992 SAFT 187 CON 58122203 Guaranteed

A06B-0331-B069#7000 FANUC SERVO MOTORS REMANUFACTURED

75 HP 55Kw 1000 RPM 6 Pole Foot Mount B3 250M 3 Phase Electric Motor

RELIANCE ELECTRIC 615055-1V USPP 6150551V

ALLEN BRADLEY 2711E-T14C15 USPP 2711ET14C15

ALLEN BRADLEY 1771-HD NSPP 1771HD

HICKOK PRO-SPEC-1000 USPP PROSPEC1000

WESTINGHOUSE 4D33811G02 USPP 4D33811G02

TEXAS INSTRUMENTS PLC PC405-6201 NSFP PC4056201

GENERAL ELECTRIC CR245P101 USPP CR245P101

Siemens 6ES5-188-3UA12 NSFP 6ES51883UA12

SIEMENS 6ES5 375-0LC21 6ES53750LC21

SIEMENS 6ES5-985-2AA11 USPP 6ES59852AA11

Siemens 6ES5 930-8MD11 Power Supply Module 14764

Siemens 6ES5 942-7UB11 6ES5942-7UB11 in Box

SIEMENS MICROMASTER 420 6SE6420-2AB11-2AA0 + BOP PANEL

RELIANCE ELECTRIC 65C-500 USPP 65C500

Texas Instruments 500-2108

Spirent Adtech AX/4000 401325 IP L3 SFP Gig Interface

VIC2-2BRI-NT/TE CISCO TWO-PORT VOICE INTERFACE CARD BRI NT AND TE

Siemens C98043-A1604-L1-5

Modicon AS-W202-010

Schneider Modicon AUTOMATION AS-BDEP-217 TSX COMPACT

Schneider Modicon AS-J890-001 MODULE Q1-5

Schneider Modicon AS-BDAP-104 USPP ASBDAP104

Schneider Modicon AS-B864-001 ASB864001 Register Output H206

Schneider Modicon AUTOMATION DEP218/AS-BDEP-218

Schneider Modicon AS-W600-006 Cable Assembly

Schneider Modicon Telemecanique TSXDMZ28DR

SE Modicon Input Module MB829-116 SURPLUS

RELEASE SuperMicro X9DRT-HIBFF MB FULL MFR

Siemens 6ES7 132-4BD00-0AA0 Output Module 24 VDC /Un

SIEMENS SINUMERIK 840D/840DE NCU 571.2 6FC5357-0BA10-0AE0

MODULE SERVO COMMUNICATION GIDDINGS AND LEWIS 501-03676-23R4

SIEMENS Simodrive 611 6SN1146-1AB00-0BA1 Infeed Module

SIEMENS SINUMERIK OP 032 6FC5203-0AB20-0AA1 NIB

SIEMENS Complete Gasket Set Arctic Cat Z 440 97-6 FC Twin 440cc

AllenBradley1769-OB32CompactI/OOutputModule

Allen Bradley SLC 500 Output Module Cat 1746-OB32 Ser. D

ABB Robot Board 3HAC1462-1 D8QC363 #29039

A06B-0127-B577#7208 FANUC SERVO MOTORS

0.1-1000MHz -80dB to +90dB Phase and levels ratio meter FK2-29 an-g Agilent HP

MODICON AS-D013-200 USPP ASD013200

ALLEN BRADLEY 1398-DDM-030 USPP 1398DDM030

ADEPT TECH 10300-46625 USPP 1030046625

GE FANUC IC600CP4210 USPP IC600CP4210

SIEMENS CMD63A800 NSFP CMD63A800

SIEMENS 6ES5685-0UA11 USPP 6ES56850UA11

ALLEN BRADLEY 2711P-B6M1A USPP 2711PB6M1A

Siemens 6ES5 928-3UB12 -- 6ES59283UB12

Siemens simatic 6ES5 523-3UA11 6ES5523-3UA11 NIB

SIEMENS 6ES5-497-4UB42 NSFP 6ES54974UB42

Siemens 6ES5 440-8MA21 6ES5 440-8MA21S5 440-8 Digital Output WARRANTY

Siemens 12/24RCE 6ED1052-1MD00-OBA7 6ED1 052-1MD00-OBA7 in Box FreeShip

Siemens EM235 6ES7 235-0KD20-0XA0 EM 235 PLC

SCHNEIDER DISCRETE INPUT 16PT 115V DEP 218/AS-BDEP-218

Square D 9001-KS11BH13

SIEMENS 6ES7-151-3AA10-0AB0 SIMATIC DP INTERFACE MODULE

WE SHIP SAME CISCO SPA-8X1GE-V2 Cisco 8-Port Gigabit Ethernet Shared Port

Siemens 6RA70 C98043-A7010-L2 Card

Siemens TP270-6 6AV6 545-0CA10-0AX0 Touchscreen Glass

Schneider Modicon TSX DAP 212 DISCRETE I/O MODULE AS-BDAP-212

Schneider Modicon AS-BDAP-212 SEALED Compact Combo ASBDAP212

Schneider Modicon AS-B824-016 USPP ASB824016

Schneider Modicon AS-884A-201 MODULE AS884A201

Schneider Modicon AS-S954-000 USPP ASS954000

Schneider Modicon AS-BFAP-209 8 PT OUTPUT

SCHNEIDER TCC-X17-TXBT CABLE 26HD/25SD MALE-FEMALE TCCXCB10002

SIEMENS 6ES7 131-4BD00-0AA0 INPUT MODULE 4 POINT

RSP720-3CXL-GE Cisco Route Switch Processor 720-3CXL Router

Siemens Digital Output Module 6ES5 441-8MA11 441-8MA12 441-8MA13 free ship

SIEMENS Sinumerik 820G 6FC3801-3AC-Z 6FC8504-1AX00 CRT Monitor Operator Panel

Schneider Automation Communication Module TSX-SCM2111 WARRANTY

SIEMENS 6SN1-162-0EA00-0DA0 NSPP 6SN11620EA000DA0

SIEMENS 6SC6100-0GA11 6SC6100-OGA11 6SC61OO-OGA11 6SC6 100-0GA11 SIMODRIVE Board

SIEMENS 6FC5-111-0CA03-0AA2 NSFP 6FC51110CA030AA2

AllenBradley6182H-12TEH4BVersaViewCE1250HTouchPanelWorkstation

Allen Bradley Versaview Industrial Monitor 6186M-12PT Sealed 2010

ABB du/dt Filter

Adtech AX/4000 Chassis w / Adtech 40128 Ethernet Module

(Good condition) SUNRISE TELECOM SUNSET ISDN SS400 w/ + + +

KEB COMBIVERT 22F4C0R-2421 USPP 22F4C0R2421

ACTUS POWER NPSA-20NN-50E8 USPP NPSA20NN50E8

FISHER ROSEMOUNT DM6004X1-EA2 NSFP DM6004X1EA2

FANUC A05B-2308-C370 USPP A05B2308C370

SCHWEITZER ENGINEERING SEL-121F-X-4256MHNB USPP SEL121FX4256MHNB

QUAD TECH 78400 NSFP 78400

RELIANCE ELECTRIC 69000-3W NSPP 690003W

Siemens 6ES5 460-4UA13 6ES54604UA13

Siemens 6ES5-927-3SA11 USPP 6ES59273SA11

SIEMENS 6ES5-430-4UA14 USPP 6ES54304UA14

Siemens 6ES5 490-7LB11 Screw Terminal Block

Siemens S5 6ES5 458-7LB11 NIB

Siemens 7XP2041-2MA00-0AA0/BB SIPROTEC 7SS60

Siemens 6ES7 321-1BL00-0AA0 -- 6ES73211BL000AA0

Square D 8005 EBU-1

NNB BECKHOFF KL5111 Bus Terminal Incremental Encoder Interface Module KL5111

WS-F6K-PFC3B CATALYST 6500 SUP720 POLICY F. CARD-3B 1YR - ASK 4 QTY

SIEMENS 6ES7-133-0BH01-0XB0 6ES71330BH010XB0 FreeShip

SIEMENS SC6000

Reliance 45C913

Schneider Modicon Gould P451 200 Series I/O Processor AS-P451-622

Schneider Modicon AS-B352-001 OUTPUT MODULE OLD STOCK FREE SAME DAY SHIPPING USA

Schneider Modicon AS-S908-012 USPP ASS908012

Schneider Modicon AS-B882-239 ASB882239 High Speed Counter

Schneider Modicon AS-B806-032 Output Module

Modicon AS-BDAP-218 16 Point Output Module

SIEMENS MOORE IDM 39IDM115ACCAN APACS INPUT DISCRETE MODULE -GUARANTEED

Siemens 6ES5 451-7LA11 -- 6ES54517LA11

SIEMENS PMI FIREFINDER PERSON MACHINE INTERFACE SYSTEM

SIEMENS Control Rack 6FC3741-0FB Z_ Genumerik 3G Unit Sinumerik 6FC 3741 OFB

VW Bluetooth Interface Communication Module 1K8035730D 1k8 035 730 D

SIEMENS 6SN1118-0DG21-0AA0 6SN1 118-0DG21-0AA0 SIMODRIVE 611-D Control Board QTY

SIEMENS Simodrive 611 6SN1118-0DM11-0AA1 6SN1 118

SIEMENS 6fc5503-0ac00-0aa0 802S Free Ship

Advantech PCI-1716L

ALLEN-BRADLEY 1771-0A AC OUTPUT MODULE

ABB AUTOMATION LINE SUBSTATION REF543A212AAA,1MRS090212-AAA

Adept Model T1 Pendant Model 68180

6SE7033-7EG50-1AA1 SIEMENS MASTERDRIVE 370AMP 200kW 380-460VAC MOTION CONTROL

HONEYWELL 4DP7APXPR-311 USPP 4DP7APXPR311

SYMAX 8030-CRM-580 NSFP 8030CRM580

CUTLER HAMMER S801T30P3S USPP S801T30P3S

COMPUMOTOR Z620-MO-25 NSFP Z620MO25

NUM 1020M USPP 1020M

MITSUBISHI MR-J2S-11KB USPP MRJ2S11KB

GEM80 8108-4003 USPP 81084003

Siemens 6ES5 262-8MB12 6ES52628MB12

Siemens 6ES5-482-7LA11 USPP 6ES54827LA11

SIEMENS 6ES5-312-3AB31 USPP 6ES53123AB31

SIEMENS Simatic S5 6ES5 455-4UA11 Output Module

Siemens 6ES5 482-3BA11 OUT / INPUT MODULE MO

SIEMENS 6FM1706-3AB20 in Box

Siemens TP177 6AV6640-0CA11-0AX0 Touchscreen Glass

Siemens 6ES5465-4UA12

Juniper PE-1OC12-ATM-MM Interface Module ATM MMF OC12 PIC M5 M7i M10 M10i Router

Zebra TLP 2844 Label printer B/W direct thermal TLP 2844

Siemens 6ES7 212-1BB23-0XB0 6ES7212-1BB23-0XB0 FreeShip

Siemens OP27 6AV3 627-1JK00-0AX0 Membrane Keypad

PLC DIRECT H4-ENET

Schneider Modicon AS-B846-001 ANALOG MULTIPLEXER

Schneider Modicon AS-584L-121 USPP AS584L121

Schneider Modicon AS-M780-048 USPP ASM780048

Schneider Modicon AS-9592-000 Memory Module D908 Exec Cart Lot of 2

Schneider Modicon 984 SERIES 7-SLOT RACK AS-H819-209

Schneider Modicon /Modicon/AS-B828-016 I/O Module

Siemens Texas Instrument 305-01AD Input Module Analog

Telemecanique HMI to Allen Bradley Logix1000 Cable

Siemens Simatic S7 Output Module 1P 6ES7 322-1HF01-0AA0 Warranty

SIEMENS 3NA5-814 USPP 3NA5814

SIEMENS SINUMERIK 840D/DE NCU 571.5 6FC5357-0BB15-0AA0 6FC53570BB150AA0 NIB

Bogen Communications SCR25A Call-In Module for SBA225 Panel

SIEMENS SIMODRIVE 6SN1145-1AA01-0AA1SINUMETIK 840D NCU-BOX 6FC5247-0AA00-0AA2

SIEMENS PANELVIEW 6FC5210-0DF20-0AA0

Advantech PCI-1610CU

Allen-Bradley 2711P-T12C4D1 PanelView Plus 1250 Touch/Enet/RS-232 64MB DC

ABB 4160 Robicon Test Station Max KV 4.76 60Hz 1200A

AccuWeb, Inc. Micro 4000 CTL 4110-01 Type 1 Enclosure

A575-030 GOULD DRIVES AS-IS

836800 WESTINGHOUSE CONTROLLERS REMANUFACTURED

SIEMENS 6ES7-742-0AC00-0BA0 USPP 6ES77420AC000BA0

ASEA BROWN BOVERI DSMB-127 USPP DSMB127

APW MCLEAN HB11-0416-G307 NSFP HB110416G307

MITSUBISHI A3H-CPU-P21 USPP A3HCPUP21

INDRAMAT DDS02.1-A100-DS03-02-FW NSFP DDS021A100DS0302

ALLEN BRADLEY 2711-K5A5 FNFP 2711K5A5

SKF 7018-ACD/P4ADGA NSFP 7018ACDP4ADGA

Siemens 6ES5-415-7AB11/6ES5415-7AB11 INPUT MODULE XLNT

SIEMENS 6ES5 464-8MB11 -- 6ES5 464-8MB11

SIEMENS 6ES5 951-7LB14

Siemens PLC INPUT MODULE6ES5 431-8MA11 WOW

Siemens 6ES7 340-1CH02-0AE0 6ES7340-1CH02-0AE0 NIB

Siemens PLC Lithium Battery SL-750 SL750 no plug NIB

pulls AP763A Hp StorageWorks MDS 600 Dual I/O Module Option Kit 498472-001